Product ID:4 CEMENT,2701080,74-451-20
MSDS Date:05/08/1989
FSC:8040
NIIN:01-107-6172
Kit Part:Y
MSDS Number: BWFPJ

BF GOODRICH ADHESIVE SYSTEMS

123 WEST BARTGES ST, DEPT 1932/1904
AKRON, OH 44311
US

Emergency Phone: 216-374-5143

Info Phone: 216-374-2824

Cage: 56277

BF GOODRICH CORP

UNIONTOWN, OH 44685 US

Telephone: 330-374-4011/ 330-374-2882

Cage: 0AJJ0

VM & P NAPHTHA/PETROLEUM DISTILLATE

CAS: 64742-89-8

Fraction By Weight: 45%

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

HEXANE (N-HEXANE) (CERCLA)

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM; 9495

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 20%

OSHA PEL 200 PPM; Z-2

ACGIH TLV: S, 50 PPM; 9495

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, LIVER,
KIDNEY, CNS, LUNG. ACUTE- HARMFUL IF INHALED, SWALLOWED/ABSORBED
THROUGH SKIN. CAUSES SEVERE EYE IRRITATION. EXCESSIVE INHALATION
CAUSES HEADACHE, DIZZINESS. DELIBERAT ELY CONCENTRATING & INHALING
MAY BE FATAL. CHRONIC- MAY CAUSE LIVER, KIDNEY, CNS, BRAIN, LUNG
DAMAGE, DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION; HEADACHE, DIZZINESS, NAUSEA, VOMITING,
INCOORDINATION, DRY SKIN, DERMATITIS, CONFUSION, UNCONSCIOUSNESS OR
COMA,
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, LIVER, KIDNEYS, CNS
MAY HAVE INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE
EXPOSURES.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:1.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER FOG, FOAM,
ALCOHOL FOAM. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/USE PUMP (EXPLOSION
PROOF). GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERINGSEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN WELL VENTILATED WAREHOUSE.
KEEP AWAY FROM HEAT, DIRECT SUNLIGHT, IGNITION SOURCES &
INCOMPATIBLE MATERIALS. GROUND CONTAINERS WHEN POURING.
Other Precautions:DANGER! EXTREMELY FLAMMABLE. EMPTY CONTAINERS RETAIN
RESIDUE AND CAN BE DANGEROUS. DO NOT PUNCTURE/WELD ON/NEAR
CONTAINER. USE WITH ADEQUATE VENTILATION. DO NOT BREATHE VAPORS.
AVOID EYES AND SKIN CON TACT. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NEOPRENE, NITRILES REQUIRED
Eye Protection:SPLASH-PROOF GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER AND
EYEWASH FACILITY
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:F3. GSA PROVIDED ONLY THIS MSDS.

HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:105F - 231F
Vapor Density:>1
Spec Gravity:0.734
Evaporation Rate & Reference:7.5 (N-BUTYL ACETATE=1)
Appearance and Odor:AMBER LIQUID - SWEET ODOR
Percent Volatiles by Volume:93.5

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, HOT SURFACES AND
OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, ALIPHATICS AND OTHERS

Waste Disposal Methods:RECLAIM MATERIAL IF POSSIBLE OR DISPOSE IN AN
APPROVED INCINERATOR OR CONTRACT WITH LICENSED CHEMICAL WASTE
DISPOSAL SERVICE. DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.